Performance Investigation of Vapor Compression Refrigeration System with Integrated Mechanical Sub-Cooling Circuit using Hydrocarbon Blends

Ahmed J. Hamad

doi:10.24237/djes.2016.09101

Authors

Ahmed J. Hamad Refrigeration and Air Conditioning Dept. Engineering Technical College–Baghdad

Keywords:

Refrigeration system, Hydrocarbon refrigerant, Mechanical sub-cooling

Abstract

This work presents an experimental study to investigate the performance of vapor compression refrigeration system using hydrocarbon mixtures. A sub-cooling circuit and phase separator are integrated with main vapor compression refrigeration system and used to predict the performance of hydrocarbon blend R-290/R-600a as alternative refrigerant with three mass fractions of (60/40, 50/50 and 40/60) and compared with R-134a. The results showed that, the enhancement in the system performance was about 14% increase in coefficient of performance, 6% increase in refrigeration effect and reduction percentage in freezing compartment temperature was in range of 12%. Lower values of pressure ratio and discharge temperature are noticed for R-290/R-600a blends comparing with R-134a. The reduction percentage in compressors power was in range of 9% during operation period. It can be concluded that the hydrocarbon refrigerants are an efficient, economically feasible and environment friendly alternative refrigerants to R-134a in vapor compression refrigeration system with sub-cooling circuit. Hydrocarbon refrigerants are flammable, therefore, safety implications of using such fluids may require specific system design and suitable operating and maintenance routines to prevent ignition and leakage sources from refrigeration system components.

Downloads

Download data is not yet available.

References

Somchai W. and Nares C., (2005) ," Experimental study of hydrocarbon mixtures to replace HFC-134a in a domestic refrigerator", Elsevier Energy conversion and Management Buildings, 46, pp 85–100.

Bjorn P. ,( 2008)," Hydrocarbons as refrigerants in small heat pump and refrigeration systems -A review", International Journal of refrigeration ,Volume 31, Issue 4, pp 552–563.

Dincer I. and Kanoglu M. ,( 2010)," Refrigeration systems and applications", second edition, John Wiley & Sons Ltd , United Kingdom,.

Klaus T. ,(1999), "Study on the potential for hydrocarbon replacements in domestic and small commercial refrigeration appliances", united nations publication, isbn 92-807-1765-0 , pp 34-38.

Browse N. and Narayana K.,( 2009)," Performance analysis of a refrigeration system using liquid-suction heat exchanger with R-12, R-134a and hydrocarbon blend", International journal of applied engineering research, February 1.

Bolaji B. O. and Akintunde M. A. ,(2010), "Theoretical investigation of the performance of some environment-friendly refrigerants in a sub-cooling heat exchanger refrigeration system", Journal of science and technology, vol. 30, No. 3, pp 101.

Ahamed J. U. and Saidur R.,( 2011),"prospect of hydrocarbon uses based on exergy analysis in the vapor compression refrigeration system" IEEE First conference on clean energy and technology CET, pp 300-304.

Vaibhav J. and Kachhwaha S. S., ( 2011)"Comparative performance study of vapour compression refrigeration system with R22/R134a/R410A/ R407C/M20", International journal of energy and environment, volume 2, Issue 2, pp.297-310.

Baskaran A. and Mathews P. K. ,( 2012),"A performance comparison of vapor compression refrigeration system using Eco friendly refrigerants of low global warming potential", International journal of scientific and research publications, volume 2, Issue 9,.

Bukola O. B. and Zhongjie H.,( 2012)," Comparative analysis of the performance of hydrocarbon refrigerants with R22 in a sub-cooling heat exchanger refrigeration system", Journal of power and energy, 226 (7), pp. 882–891.

Bukola O. B. and Zhongjie H.,(2013)," Thermodynamic analysis of hydrocarbon refrigerants in a sub-cooling refrigeration system", Journal of engineering research vol.1-(1), June, pp. 317-333.

Ashish K. P. and Gupta R. C.,(2013)," Effect of sub cooling and superheating on vapor compression refrigeration systems using R-22 alternative refrigerants", International journal of emerging trends in engineering and development, Issue 3, vol.1, January, pp. 521-531.

Nguyen Q. M. and Neil J. H.,(2006)," Improved vapor compression refrigeration cycles: literature review and their application to heat pumps", international refrigeration and air conditioning conference, Purdue university, paper 795.

Chang Y. S. and Kim M.S. ,(2000)," Performance and heat transfer characteristics of hydrocarbon refrigerants in a heat pump system", Elsevier international journal of refrigeration, 23 , pp. 232-242.

Heierli U. , (1997)," Refrigeration appliances using hydrocarbon refrigerants, "manual prepared by Cool concerns", ECOFRIG publication, United Kingdom.

Mohd A. N. and Chidanand M. ,(2014)," Experimental analysis of refrigerator by replacing conventional HFC refrigerants with hydrocarbons ", Journal of Mechanical and Civil Engineering (IOSR-JMCE), e-ISSN: 2278-1684, p-ISSN: 2320-334X , PP 01-05.